Commercial kitchen extraction in Surrey

Kitchen extraction in Surrey starts with a survey of the cooking line and the discharge route.

Across Surrey the job is priced the same way wherever you are: what is fitted, how long it takes and how far we travel. Towns we cover include Guildford, Esher, Redhill, Staines and Banstead.

Kitchen extraction in Surrey at a glance

Area: Surrey
Towns listed: 35, largest Woking
Postcode districts: TW16, TW15, TW16, KT12, TW16 and GU3
Price region: South East
Survey: Free survey (UK mainland)

How we do it

Where gas appliances are used, the gas supply is normally interlocked with the ventilation so cooking cannot run without extract, as BS 6173 sets out. Planning conditions often require odour control and limits on noise at the discharge. We fit out new restaurants, cafés, takeaways and staff canteens, and replace or extend extract when menus or equipment change.

Extract fans and ductwork

Fans sized to the canopy, with access panels for cleaning.

Make-up air

Tempered fresh air to replace what is extracted.

Odour control and interlocks

Carbon filters or other odour control to meet planning, and gas interlock systems.

Guide prices in Surrey

Commercial kitchen extraction guide prices in Surrey
Work	Guide price
Kitchen canopy and extract system for a café or takeaway (canopy up to 2 m) (per kitchen)	£6,550–£13,150 + VAT
Kitchen canopy, extract and make-up air for a restaurant (3 to 4 m canopy) (per kitchen)	£14,250–£32,950 + VAT
TR19 Grease kitchen extract clean with post-clean report, single canopy system (per clean)	£435–£975 + VAT

South East rates shown. Prices exclude VAT. The fixed price is confirmed in writing after we have seen the job.

Signs it is time to call us

Smoke or heat building up in the kitchen
Planning conditions on odour or noise
Gas interlock missing or not working

Rules in England

English building work follows Approved Document F (2021 edition) for ventilation rates, installation and commissioning. Kitchen extract is commonly cleaned to BESA TR19 Grease, and gas appliances are normally interlocked with the ventilation following BS 6173.

How the job runs

Survey
Design
Fabricate and install
Interlock
Commission

Towns we cover in Surrey

Questions about commercial kitchen extraction in Surrey

Which rules apply to ventilation in Surrey?

In England, ventilation in new and altered homes is covered by Approved Document F of the Building Regulations. Landlords also have duties under the Housing Health and Safety Rating System, and workplaces must be ventilated under the Workplace (Health, Safety and Welfare) Regulations 1992.

What is make-up air?

Make-up air is fresh air brought back into the kitchen to replace what the canopy extracts, so doors do not slam and gas appliances burn properly.

How often does kitchen extract need cleaning?

Under BESA TR19 Grease, minimum cleaning intervals are every 3 months for heavy use, 6 months for moderate use and 12 months for light use.

Which towns in Surrey do you cover?

All of Surrey, including Guildford, Esher, Redhill, Staines and Banstead. If your town is not listed, send the postcode and we will confirm.

Are prices different in Surrey?

Our guide prices are adjusted by region. In Surrey we use South East rates, so kitchen canopy and extract system for a café or takeaway (canopy up to 2 m) is typically £6,550 to £13,150 + VAT per kitchen.

We can provide technical details for your Surrey planning application.